Product ID:6460-4702 H/S POLY GRAY PRIMER, 6460-4702
MSDS Date:02/26/1992
FSC:8010
NIIN:00N066868
MSDS Number: CBWJM

CARDINAL INDUSTRIAL FINISHES

1329 POTRERO AVE
SOUTH EL MONTE, CA 91733
US

Emergency Phone: 818-444-9274

Info Phone: 818-444-9274

Preparer: RICHARD STEWART

Cage: 65860

CARDINAL INDUSTRIAL FINISHES

SOUTH EL MONTE, CA 91733 US

Telephone: 818-444-9274 OR 213-283-9335

Cage: 65860

2.1 @ 68F

CAS: 110-43-0

RTECS: MJ5075000

Fraction By Weight: 10%

OSHA PEL 100 PPM

ACGIH TLV: 50 PPM

ACETIC ACID, BUTYL ESTER; (N-BUTYL ACETATE) (CERCLA) VP

CAS: 123-86-4

RTECS: AF7350000

Fraction By Weight: 10%

OSHA PEL 150 PPM

ACGIH TLV: 150 PPM; 200 STEL

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

PHOSPHORIC ACID, ZINC SALT; (ZINC PHOSPHATE)

RTECS: TD0600000

Fraction By Weight: 10%

OSHA PEL 15 MG/M3 (MFR)

ACGIH TLV: 10 MG/M3 (MFR)

2-BUTANONE; (METHYL ETHYL KETONE) (SARA 313) (CERCLA) VP

CAS: 78-93-3

RTECS: EL6475000

Fraction By Weight: 2%

OSHA PEL 200 PPM

ACGIH TLV: 200 PPM; 300 STEL

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

2.90 LB/GAL

RTECS: 9999999VO

OSHA PEL N/K

ACGIH TLV: N/K

CALIFORNIA TO CAUSE CANCER &/OR BIRTH DEFECTS OR

RTECS: 9999999ZZ

OR ADMINISTRATIVE CONTROLS SHOULD BE IMPLEMENTED

RTECS: 9999999ZZ

ALCOHOL COATED OR POLYETHYLENE.

RTECS: 9999999ZZ

CLOTHING AND CHEMICAL RESISTANT BOOTS.

RTECS: 9999999ZZ

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:INHAL: HDCH, FATG, WEARINESS, NAUS,
VOMIT, DIZZ, STUPOR, DROW, DISTURBED VISION, COUGH & UNCON. SKIN:
PRLNGD CNTCT CAN CAUSE MOD IRRIT, DEFAT & DERM. TINGLING SENSATION.
SKIN ABSORPTION:MOD IRRIT, DEF AT, DERM, DRY SKIN, RASH. EYES: CAN
CAUSE SEV IRRIT, REDNESS, TEARING & BLURRED VISION. INGEST: BREATH
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: SMELLS OF SOLV. IRRIT OF LIPS &
MOUTH, GI IRRIT, NAUS, DIARR, DROW, LOSS OF CONSCIOUSNESS. STATE OF
SHOCK, WEAK & RAPID PULSE, COLD-PALE COMPLEXION. CHRONIC: MAY PRDCE
LIVER & KIDNEY DMG, PE RSISTANT COUGH, BRAIN DMG & MAY EVEN CAUSE
DEATH. OVEREXP HAS APPARENTLY BEEN FOUND TO CAUSE FOLLOWING EFTS IN
(SUPDAT)
Medical Cond Aggravated by Exposure:PRE-EXISTING RESPIRATORY
CONDITIONS, PRE-EXISTING SKIN DISORDERS, LIVER AND KIDNEY
DISORDERS.

First Aid:EYES: FLUSH W/PLENTY OF WATER FOR AT LEAST 15-30 MINUTES. GET
MEDICAL ATTENTION. SKIN: WASH EXPOSED AREA W/MILD SOAP & WATER FOR
15 MINUTES. REMOVE CONTAMD CLOTHING. INHAL: REMOVE TO FRESH AIR. IF
BRE ATHING IS DIFFICULT, ADMINISTER OXYGEN.IF BREATHING HAS
STOPPED, GIVE ARTIFICIAL RESPIRATION. GET MEDICAL ATTENTION.
INGEST: DO NOT INDUCE VOMITING. KEEP VICTIM WARM & SEEK IMMED
MEDICAL ATTENTION.

Flash Point Method:TCC
Flash Point:24.0F,-4.4C
Lower Limits:1.1%
Upper Limits:11.4%
Extinguishing Media:FOAM, ALCOHOL FOAM, CARBON DIOXIDE, DRY CHEMICAL,
WATER FOG.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:KEEP CNTNRS TIGHTLY CLSD. ISOLATE FROM
HEAT, SPKS, ELEC EQUIP & OPEN FLAME. CLSD CNTNRS MAY EXPLODE WHEN
EXPOS TO EXTREME HEAT. DURING EMER CNDTNS, (SUPDAT)

Spill Release Procedures:FOLLOW INSTRUCTIONS TO PREVENT HEALTH HAZARDS.
ELIMINATE ALL SOURCES OF IGNITION. ABSORB LIQUIDS IN ABSORBENT
MATERIAL AND PREVENT SPREADING TO GROUND WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:STORE AT ROOM TEMPERATURE AWAY FROM
HEAT SOURCES, AND HAVE LIDS TIGHTLY CLOSED.
Other Precautions:CONTAINERS MAY BE HAZARDOUS WHEN EMPTIED. SINCE
EMPTIED CONTAINERS MAY RETAIN PRODUCT RESIDUALS (VAPORS, LIQUID
AND/OR SOLIDS), ALL PRECAUTIONS GIVEN IN MSDS MUST BE OBSERVED.

Respiratory Protection:IF TLV OF PROD/ANY COMPONENT IS EXCEEDED
NIOSH/MSHA APPRVD AIR SUPPLIED RESP IS ADVISED IN ABSENCE OF
ENVIRON CTL. OSHA REGS ALSO PERMIT OTHER NIOSH/MSHA APPRVD RESPS
UNDER SPECIFIED CNDTNS (SEE SFTY EQUIP SUPPLIER). ENGINEERING (ING
7)
Ventilation:PROVIDE SUFFICIENT MECHANICAL (GENERAL AND/OR LOCAL EXHAUST
)VENTILATION TO MAINTAIN EXPOSURE BELOW THE TLVS.
Protective Gloves:RESISTANT SUCH AS POLYVINYL (ING 8)
Eye Protection:ANSI APPRVD CHEM WORKERS GOGGLES .
Other Protective Equipment:ANSI APPRVD EYE WASH & DELUGE SHOWER . PVNT
RPTD/PRLNGD SKIN CNTCT W/PROT HANDCREAM. WEAR IMPERVIOUS (ING 9)
Work Hygienic Practices:WASH HANDS BEFORE EATING OR USING THE REST
ROOM. SMOKE IN SMOKING AREAS ONLY.
Supplemental Safety and Health
EXPLO HAZS: OVEREXP TO DECOMP PRODS MAY CAUSE HLTH HAZ. SYMPS MAY NOT
BE IMMED APPARENT. OBTAIN MED ATTN. EFTS OF OVEREXP: LAB
ANIMALS:LIVER ABNORMS, KIDNEY & LUNG DMG. ALSO OVEREXP HAS BEEN
SUGGESTED TO CAUSE CARD & LIVER ABNORMS, KIDNEY & LUNG DMG IN
HUMANS. WARNING:DETECTABLE AMTS OF CHEM KNOWN TO STATE OF (ING 6)

Boiling Pt:B.P. Text:>175F,>79C
Vapor Pres:SEE INGS
Vapor Density:HVR/AIR
Spec Gravity:1.7 (H*2O=1)
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:NONSOLUBLE
Appearance and Odor:SOLVENT ODOR.

Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH STRONG OXIDIZERS.
Stability Condition to Avoid:EXTREMELY HIGH TEMPERATURES.
Hazardous Decomposition Products:HAZARDOUS DECOMPOSITION MAY PRODUCE
CARBON DIOXIDE AND/OR CARBON MONOXIDE.

Waste Disposal Methods:RECYCLE LIQUIDS IF POSSIBLE. INCINERATE SOLIDS
IN ACCORDANCE WITH APPLICABLE FEDERAL, STATE AND LOCAL REGULATIONS.
AS A LAST RESORT NEUTRALIZE AND LANDFILL IN ACCORDANCE WITH LOCAL,
STATE AND FEDERAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.